Abstract
We study the relationship between the surface mechanical load represented by distributed acoustic impedance and the current density distribution in a shear mode piezoelectric plate acoustic wave resonator. A theoretical analysis based on the theory of piezoelectricity and trigonometric series is performed. In the specific and basic case when the surface load is due to a local mass layer, numerical results show that the current density concentrates under the mass layer and is sensitive to the physical as well as geometric parameters of the mass layer such as its location and size. This provides the theoretical foundation for predicting the surface impedance pattern from the current density distribution, which is fundamental to the relevant acoustic wave sensors.
Article PDF
Similar content being viewed by others
References
BOTTOM, V. E. Introduction to Quartz Crystal Unit Design, Van Nostrand Reinhold, New York (1982)
SALT, D. Hy-Q Handbook of Quartz Crystal Devices, Van Nostrand Reinhold, Berkshire (1987)
LAKIN, K. M. A review of thin-film resonator technology. IEEE Microwave Magazine, 4(2), 61–67 (2003)
TIERSTEN, H. F. Linear Piezoelectric Plate Vibrations, Plenum, New York (1969)
CAMPBELL, C. K. Surface Acoustic Wave Devices for Mobile and Wireless Communications, Academic Press, Orlando (1998)
HASHIMOTO, K. Y. Surface Acoustic Wave Devices in Telecommunications, Springer, Berlin (2000)
SAUERBREY, G. Verwendung von schwingquarzen zur wägung dünner schichten und zur mikrowägung. Ztschrift Für Physik, 155(2), 206–222 (1959)
KANAZAWA, K. K. and GORDON II, J. G. The oscillation frequency of a quartz resonator in contact with a fluid. Analytica Chimica Acta, 175, 99–105 (1985)
REED, C. E., KANAZAWA, K. K., and KAUFMAN, J. H. Physical description of a viscoelastically loaded AT-cut quartz resonator. Journal of Applied Physics, 68(5), 1993–2001 (1990)
MARTIN, S. J., GRANSTAFF, V. E., and FRYE, G. C. Characterization of a quartz crystal microbalance with simultaneous mass and liquid loading. Analytical Chemistry, 63(20), 2272–2281 (1991)
DUNCAN-HEWITT, W. C. and THOMPSON, M. Four-layer theory for the acoustic shear wave sensor in liquids incorporating interface slip and liquid structure. Analytical Chemistry, 64(1), 94–105 (1992)
JING, Y., CHEN, J., CHEN, X., and GONG, X. Frequency shift of thickness-shear vibrations of AT-cut quartz resonators due to a liquid layer with the electrode stiffness considered. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 54(7), 1290–1292 (2007)
LINK, M., SCHREITER, M., WEBER, J., PRIMIG, R., PITZER, D., and GABL, R. Solidly mounted ZnO shear mode film bulk acoustic wave resonators for sensing applications in liquids. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 53(2), 492–496 (2006)
FU, Y. Q., LUO, J. K., DU, X. Y., FLEWITT, A. J., LI, Y., MARKX, G. H., WALTON, A. J., and MILNE, W. I. Recent developments on ZnO films for acoustic wave based bio-sensing and microfluidic applications: a review. Sensors & Actuators B: Chemical, 143(2), 606–619 (2010)
ZHANG, Y. and BAO, Y. Sensitivity analysis of multi-layered C-axis inclined zigzag zinc oxide thin-film resonators as viscosity sensors. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 61(3), 525–534 (2014)
LIU, J., DU, J. K., WANG, J., and YANG, J. S. Thin film bulk acoustic wave piezoelectric resonators with circular ring driving electrodes for mass sensing. Integrated Ferroelectrics, 192(1), 57–66 (2018)
CUMPSON, P. J. and SEAH, M. P. The quartz crystal microbalances; radial/polar dependence of mass sensitivity both on and off the electrodes. Measurement Science & Technology, 1 (7), 544–555 (1990)
TATSUMA, T., WATANABE, Y., and OYAMA, N. Multichannel quartz crystal microbalances. Analytical Chemistry, 71(17), 3632–3636 (1999)
SHEN, F. and LU, P. Influence of interchannel spacing on the dynamical properties of multichannel quartz crystal microbalance. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 50(6), 668–675 (2003)
LIU, N., YANG, J. S., WANG, J., and KOSINSKI, J. A. Analysis of a monolithic, nonperiodic array of quartz crystal microbalances. Japanese Journal of Applied Physics, 52(7), 77301 (2013)
TIERSTEN, H. F. Perturbation theory for linear electroelastic equations for small fields superposed on a bias. The Journal of the Acoustical Society of America, 64(3), 832–837 (1978)
LU, Y. P., TANG, H. Y., FANG, S., and WANG, Q. Ultrasonic fingerprint sensor using a piezoelectric micromachined ultrasonic transducer array integrated with complementary metal oxide semiconductor electronics. Applied Physics Letters, 106, 263503 (2015)
PARK, H. and ROH, Y. Design of ultrasonic fingerprint sensor made of 1–3 piezocomposites by finite element method. Japanese Journal of Applied Physics, 56(1), 07JD06 (2017)
BICZ, W., GUMIENNY, Z., and PLUTA, M. Ultrasonic sensor for fingerprints recognition. Proceedings of SPIE — The International Society for Optics and Photonics, 2634, 104–111 (1995)
CHOI, W. Y., KANG, K. C., and PARK, K. K. Ultrasonic fingerprint sensor in underglass prototype using impedance mismatching. Journal of Mechanical Science and Technology, 34(2), 1–9 (2020)
FUNG, S., LU, Y., TANG, H. Y., TSAI, J. M., DANEMAN, M., BOSER, B. E., and HORSLEY, D. A. Theory and experimental analysis of scratch resistant coating for ultrasonic fingerprint sensors. 2015 IEEE International Ultrasonics Symposium, IEEE, Taipei (2015)
JIANG, X. Y., TANG, H. Y., LU, Y., NG, E. J., TSAI, J. M., BOSER, B. E., and HORSLEY, D. A. Ultrasonic fingerprint sensor with transmit beam forming based on a PMUT array bonded to CMOS circuitry. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 64(9), 1401–1408 (2017)
SCHMITT, R. M., ZEICHMAN, J., CASANOVA, A. C., and DELONG, D. Model based development of a commercial, acoustic fingerprint sensor. 2012 IEEE International Ultrasonics Symposium, IEEE, Dresden (2012)
TANG, H. Y., LU, Y., JIANG, X., NG, E. J., TSAI, J. M., HORSLEY, D. A., and BOSER, B. E. 3-D ultrasonic fingerprint sensor-on-a-chip. IEEE Journal of Solid-State Circuits, 51(11), 2522–2533 (2016)
BLEUSTEIN, J. L. A new surface wave in piezoelectric materials. Applied Physics Letters, 13(12), 412–413 (1968)
YANG, J. S., CHEN, Z. G., and HU, Y. T. Vibration of a thickness-twist mode piezoelectric resonator with asymmetric, non-uniform electrodes. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 55(4), 841–848 (2008)
YANG, J. S. Antiplane Motions of Piezoceramics and Acoustic Wave Devices, World Scientific, Singapore (2010)
TIERSTEN, H. F. Wave propagation in an infinite piezoelectric plate. Journal of the Acoustical Society of America, 35, 234–239 (1963)
YANG, J. S. Vibration of Piezoelectric Crystal Plates, World Scientific, Singapore (2013)
TIERSTEN, H. F. and STEVENS, D. S. An analysis of thickness-extensional trapped energy resonant device structures with rectangular electrodes in the piezoelectric thin film on silicon configuration. Journal of Applied Physics, 54(10), 5893–5910 (1983)
ZHAO, Z. N., QIAN, Z. H., WANG, B., and YANG, J. S. Energy trapping of thickness-extensional modes in thin film bulk acoustic wave resonators. Journal of Mechanical Science and Technology, 29(7), 2767–2673 (2015)
ZHAO, Z. N., QIAN, Z. H., and WANG, B. Energy trapping of thickness-extensional modes in thin film bulk acoustic wave filters. AIP Advances, 6(1), 993–995 (2016)
ZHAO, Z. N., QIAN, Z. H., and WANG, B. Vibration optimization of ZnO thin film bulk acoustic resonator with ring electrodes. AIP Advances, 6(4), 1735–1739 (2016)
YANG, J. S., ZHOU, H. G., and ZHANG, W. P. Thickness-shear vibration of rotated Y-cut quartz plates with relatively thick electrodes of unequal thickness. IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control, 52(5), 918–922 (2005)
DU, J. K., XIAN, K., WANG, J., and YANG, J. S. Thickness vibration of piezoelectric plates of 6 mm crystals with tilted six-fold axis and two-layered thick electrodes. Ultrasonics, 49(2), 149–152 (2009)
AULD, B. A. Acoustic Fields and Waves in Solids, John Wiley and Sons, New York (1973)
KUMAR, Y., RANGRA, K., and AGARWAL, R. Design and simulation of FBAR for quality factor enhancement. MAPAN-Journal of Metrology Society of India, 32, 113–119 (2017)
KHINE, L., WONG, L. Y. L., SOON, J. B. W., and TSAI, J. M. FBAR resonators with sufficient high Q for RF filter implementation. Advanced Materials Research, 254, 70–73 (2011)
TAY, K. W., HUANG, C. L., and WU, L. Highly c-axis oriented thin AlN films deposited on gold seed layer for FBAR devices. Journal of Vacuum Science & Technology B, 23(4), 1474–1479 (2005)
YANG, C. M., UEHARA, K., KIM, S. K., and KAMEDA, S. Highly c-axis-oriented AlN film using MOCVD for 5 GHz-band FBAR filter. 2003 IEEE Ultrasonics Symposium Proceedings, IEEE, New York, 171–173 (2003)
WINGQVIST, G., YANTCHEV, V., and KATARDJIEV, I. Mass sensitivity of multilayer thin film resonant BAW sensors. Sensors & Actuators A: Physical, 148(1), 88–95 (2008)
ZHOU, C. J., YANG, Y., SHY, Y., CAI, H. L., REN, T. L., CHAN, M., ZHOU, J., JIN, H., DONG, S. R., and YANG, C. Y. Visible-light photoresponse of AlN-based film bulk acoustic wave resonator. Applied Physics Letters, 102(19), 1–3 (2013)
Author information
Authors and Affiliations
Corresponding author
Additional information
Project supported by the National Natural Science Foundation of China (Nos. 11672141 and 11972199), the Special Research Funding from the Marine Biotechnology and Marine Engineering Discipline Group in Ningbo University, and the K. C. Wong Magana Fund through Ningbo University
Rights and permissions
This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Liu, J., Du, J., Wang, J. et al. Effects of surface impedance on current density in a piezoelectric resonator for impedance distribution sensing. Appl. Math. Mech.-Engl. Ed. 42, 677–688 (2021). https://doi.org/10.1007/s10483-021-2723-9
Received:
Revised:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10483-021-2723-9