Skip to main content
SpringerLink
Log in

Crystallization of cellulose microfibrils in wood cell wall by repeated dry-and-wet treatment, using X-ray diffraction technique

  • Original Paper
  • Published:
Cellulose Aims and scope Submit manuscript

Abstract

The purpose of this study is to investigate the effect of repeated moisture change on the crystallinity and crystal size of cellulose microfibrils (CMF) in sugi (Cryptomeria japonica D.Don) and karamatsu (Larix kaempferi Gord.) wood cell wall. Based on obtained results, we discussed the qualitative change in the fine structure of CMF caused by repeated dry-and-wet (RDW) treatments. Green quarter-sawn specimens (5 × 16 × 15 mm in thickness × length × width) and microcrystalline cellulose powder (Avicel) were prepared, and these specimens were subjected to 7 times at most of heated or unheated RDW treatments. After giving RDW treatments, specimens were seasoned to the fiber saturated point and absolutely dried. Wide angle X-ray diffraction measurements were adopted to determine the crystallinity and the crystal size in each condition. Results indicate that crystallinity and crystal size in wood specimens gradually increased with the progress of heated or unheated RDW treatments, while no such increases were observed in Avicel powder. Those results suggest that RDW treatments promote the crystallization of CMF in wood cell wall, regardless of heating. We presume that noncrystalline cellulose forms hydrogen bonding with the cellulose at the surface of crystalline region with the progress of RDW treatments, thus enlarging the crystal size. Avicel powder did not show features that were observed in wood specimens by RDW treatments, because it contained few noncrystalline cellulose.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8

Similar content being viewed by others

References

  • Abe K, Yamamoto H (2005) Mechanical interaction between cellulose microfibril and matrix substance in wood cell wall determined by X-ray diffraction. J Wood Sci 51:334–338

    Article  CAS  Google Scholar 

  • Abe K, Yamamoto H (2006) Change in mechanical interaction between cellulose microfibril and matrix substance in wood cell wall induced by hygrothermal treatment. J Wood Sci 52:107–110

    Article  Google Scholar 

  • Alexander LE (1969) X-ray diffraction in polymer science. Wiley-Interscience, Amsterdam, pp 423–424

    Google Scholar 

  • Andersson S, Serimaa R, Paakkari T, Saranpää P, Pesonen E (2003) Crystallinity of wood and the size of cellulose crystallites in Norway spruce (Picea abies). J Wood Sci 49:531–537

    Google Scholar 

  • Bhuiyan MTR, Hirai N, Sobue N (2000) Changes of crystallinity in wood cellulose by heat treatment under dried and moist conditions. J Wood Sci 46:431–436

    Article  CAS  Google Scholar 

  • Bonarski JT, Olek W (2011) Application of the crystalline volume fraction for characterizing the ultrastructural organization of wood. Cellulose 18:223–235

    Article  Google Scholar 

  • Brennan M, McLean JP, Altaner CM, Ralph J, Harris PJ (2012) Cellulose microfibril angles and cell-wall polymers in different wood types of Pinus radiata. Cellulose 19:1385–1404

    Article  CAS  Google Scholar 

  • Cave ID (1969) The longitudinal Young’s modulus of Pinus radiata. Wood Sci Technol 3:40–48

    Article  Google Scholar 

  • Clair B, Alméras T, Yamamoto H, Okuyama T, Sugiyama J (2006) Mechanical behavior of cellulose microfibrils in tension wood, in relation with maturation stress generation. Biophys J 91:1128–1135

    Article  CAS  Google Scholar 

  • Esteves BM, Pereira HM (2009) Wood modification by heat treatment: a review. Bioresources 4:370–404

    CAS  Google Scholar 

  • Fengel D, Wegener G (1984) Wood chemistry, ultrastructure, reactions. Walter de Gruyter, Amsterdam

    Google Scholar 

  • Fernandes AN, Thomas LT, Altaner CM, Callow P, Forsyth VT, Apperley DC, Kennedy CJ, Jarvis MC (2011) Nanostructure of cellulose microfibrils in spruce wood. Proc Natl Acad Sci USA 108:E1195–E1203

    Article  Google Scholar 

  • Hill SJ, Kirby NM, Mudie ST, Hawlay AM, Ingham B, Franich RA, Newman RH (2010) Effect of drying and rewetting of wood on cellulose molecular packing. Holzforschung 64:421–427

    CAS  Google Scholar 

  • Inagaki T, Siesler HW, Mitsui K, Tsuchikawa S (2010) Difference of the crystal structure of cellulose in wood after hydrothermal and aging degradation: a NIR spectroscopy and XRD study. Biomacromolecules 11:2300–2305

    Article  CAS  Google Scholar 

  • Isogai A, Usuda M (1990) Crystallinity indexes of cellulosic materials. Sen I Gakkaishi 46:62–67

    Article  Google Scholar 

  • Ito Y, Tanahashi M, Shigematsu M, Shinoda Y (1998) Compressive-molding of wood by high-pressure steam-treatment: part 2. Mechanism of permanent fixation. Holzforschung 52:217–221

    Article  CAS  Google Scholar 

  • Kai M, Usuda M, Nakano J (1972) Fine structure of red pine earlywood and latewood cellulose. Mokuzai Gakkaishi 18:565–5693

    CAS  Google Scholar 

  • Kojima Y, Yamamoto H (2004) Properties of the cell wall constituents in relation to the longitudinal elasticity of wood. Part 2: origin of the moisture dependency of the longitudinal elasticity of wood. Wood Sci Technol 37:427–434

    Article  CAS  Google Scholar 

  • Kollmann FFP, Côté WA (1984) Principles of wood science and technology, vol 1: solid wood. Springer, Berlin, New York

    Google Scholar 

  • Kubojima Y, Okano T, Ohta M (1998) Vibrational properties of sitka spruce heat-treated in nitrogen gas. J Wood Sci 44:73–77

    Article  Google Scholar 

  • Leonardon M, Altaner CM, Vihermaa L, Jarvis MC (2010) Wood shrinkage: influence of anatomy, cell wall architecture, chemical composition and cambial age. Eur J Wood Prod 68:87–94

    Article  CAS  Google Scholar 

  • Leppänen K, Bjurhager I, Peura M, Kallonen A, Suuronen JP, Penttilä P, Love J, Fagerstedt K, Serimaa R (2011) X-ray scattering and microtomography study on the structural change of never-dried silver birch, European aspen and hybrid aspen during drying. Holzforchung 65:865–873

    Article  Google Scholar 

  • Matsuo M, Yokoyama M, Umemura K, Gril J, Yano K, Kawai S (2010) Color changes in wood during heating: kinetic analysis by applying a time-temperature superposition method. Appl Phys A 99:47–52

    Article  CAS  Google Scholar 

  • Meylan BA (1972) The influence of microfibril angle on the longitudinal shrinkage–moisture content relationship. Wood Sci Technol 6:293–301

    Article  Google Scholar 

  • Nakai T, Yamamoto H (2007) Properties of piezoelectric voltage considering the microscopic structure of wood cell walls. Holzforschung 61:95–100

    Article  CAS  Google Scholar 

  • Nishimura H, Okano T, Asano I (1981) Fine structure of wood cell walls 1. Structural features of noncrystalline substances in wood cell walls. Mokuzai Gakkaishi 27:611–617

    Google Scholar 

  • Noguchi T, Obataya E, Ando K (2012) Effects of aging on the vibrational properties of wood. J Cult Herit 13:s21–s25

    Article  Google Scholar 

  • Okano T (1970) Determination of crystallinity index of the wood by X-ray-with orientated specimens. Mokuzai Gakkaishi 60:257–261

    Google Scholar 

  • Olek W, Bonaski J (2012) Influence of cyclic sorption on wood ultrastructure. Bioresources 7:1729–1739

    Google Scholar 

  • Peura M, Kölln K, Grotkopp I, Saranpää P, Müller M, Serimaa R (2007) The effect of axial strain on crystalline cellulose in Norway spruce. Wood Sci Technol 41:565–583

    Article  CAS  Google Scholar 

  • Saito Y, Shida S, Ohta M, Yamamoto H, Tai T, Ohmura W, Makihara H, Noshiro S, Goto O (2008) Deterioration character of aged timbers insect damage and material aging of rafters in a historic building of Fukushoji-temple. Mokuzai Gakkaishi 54:255–262

    Article  CAS  Google Scholar 

  • Segal L, Creely JJ, Martin AE, Conrad CM (1959) An empirical method for estimating the degree of crystallinity of native cellulose using the X-ray diffractometer. Text Res J 29:786–794

    Article  CAS  Google Scholar 

  • Sobue N, Hirai N, Asano I (1970) Studies of wood by X-ray variation of crystalline state in the stem of sugi (Cryptomeria japonica D. Don). Mokuzai Gakkaishi 16:262–267

    Google Scholar 

  • Sobue N, Shibata Y, Mizusawa T (1992) X-ray measurement of lattice strain of cellulose crystals during the shrinkage of wood in the longitudinal direction. Mokuzai Gakkaishi 38:336–341

    CAS  Google Scholar 

  • Sugino H, Sugimoto H, Miki T, Kanayama K (2007) Fine structure changes of wood during moisture adsorption and desorption process analyzed by X-ray diffraction measurement. Mokuzai Gakkaishi 53:82–89

    Article  CAS  Google Scholar 

  • Thygesen A, Oddershede J, Lilholt H, Thomsen AB, Ståhl K (2005) On the determination of crystallinity and cellulose content in plant fibres. Cellulose 12:563–576

    Article  CAS  Google Scholar 

  • Toba K, Yamamoto H, Yoshida M (2012a) Mechanical interaction between cellulose microfibrils and matrix substances in wood cell walls induced by repeated wet-and-dry treatment. Cellulose 19:1405–1412

    Article  CAS  Google Scholar 

  • Toba K, Yamamoto H, Yoshida M (2012b) Micromechanical detection of growth stress in wood cell wall by wide-angle X-ray diffraction (WAX). Holzforschung. doi:10.1515/hf-2012-0080

    Google Scholar 

  • Udaka E, Furuno T (2003) Change of crystalline structure of compressed wood by treatment with a closed heating system. Mokuzai Gakkaishi 49:1–6

    CAS  Google Scholar 

  • Wang SY, Chiu CM (1990) The wood properties of Japanese cedar originated by seed and vegetative reproduction in Taiwan IV. The variation of the degree of crystallinity of cellulose. Mokuzai Gakkaishi 36:909–916

    CAS  Google Scholar 

  • Wellwood RW, Sastry CBR, Micko MM, Paszner L (1975) X-ray diffraction studies: a statistical evaluation of crystallinity index of Ramie by different methods. Mokuzai Gakkaishi 21:272–277

    Google Scholar 

  • Yamamoto H, Kojima Y (2002) Properties of cell wall constituents in relation to longitudinal elasticity of wood. Part 1. Formulation of the longitudinal elasticity of an isolated wood fiber. Wood Sci Technol 36:55–74

    Article  CAS  Google Scholar 

  • Yamamoto H, Sassus F, Ninomiya M, Gril J (2001) A model of anisotropic swelling and shrinking process of wood. Part 2. A simulation of shrinking wood. Wood Sci Technol 35:167–181

    Article  CAS  Google Scholar 

  • Yamamoto H, Ruelle J, Arakawa Y, Yoshida M, Clair B, Gril J (2010) Origin of the characteristic hygro-mechanical properties of the gelatinous layer in tension wood from kunugi oak (Quercus acutissima). Wood Sci Technol 44:149–163

    Article  CAS  Google Scholar 

  • Yildiz S, Gümüskaya E (2007) The effects of thermal modification on crystalline structure of cellulose in soft and hardwood. Build Environ 42:62–67

    Article  Google Scholar 

  • Yokoyama M, Gril J, Matsuo M, Yano H, Sugiyama J, Clair B, Kubodera S, Mitsutani T, Sakamoto M, Ozaki H, Imamura M, Kawai S (2009) Mechanical characteristics of aged hinoki wood from Japanese historical buildings. C R Phys 10:601–611

    Article  CAS  Google Scholar 

  • Zabler S, Paris O, Burgert I, Fratzl P (2010) Moisture changes in the plant cell wall force cellulose crystallites to deform. J Struct Biol 171:133–141

    Article  CAS  Google Scholar 

  • Zhu Y, Ren X, Wu C (2004) Influence of alkali treatment on the structure of new cell fibers. J Appl Poly Sci 93:1731–1735

    Article  CAS  Google Scholar 

Download references

Acknowledgments

The authors greatly appreciate cooperation of Mr. Yasuji Imaizumi, Mr. Naoki Takabe, and Mr. Norio Yamaguchi from the Nagoya University Experimental Forest for their assistance in logging the sample trees. The authors also thank Mr. Sujan K.C., a Graduate student, Nagoya University, Japan, for valuable discussions and for English correction.

Author information

Authors and Affiliations

  1. Graduate School of Bioagricultural Sciences, Nagoya University, Nagoya, 464-8601, Japan

    Keisuke Toba, Hiroyuki Yamamoto & Masato Yoshida

Authors
  1. Keisuke Toba
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Hiroyuki Yamamoto
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Masato Yoshida
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Hiroyuki Yamamoto.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Toba, K., Yamamoto, H. & Yoshida, M. Crystallization of cellulose microfibrils in wood cell wall by repeated dry-and-wet treatment, using X-ray diffraction technique. Cellulose 20, 633–643 (2013). https://doi.org/10.1007/s10570-012-9853-7

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10570-012-9853-7

Keywords

Search

Navigation