Abstract
Inherent nonlinearities of piezoelectric materials are pronounced in various engineering applications such as sensing, actuation, combined applications for vibration control, and energy harvesting from dynamical systems. The existing literature focusing on the dynamics of electroelastic structures made of piezoelectric materials has explored such nonlinearities separately for the problems of mechanical and electrical excitation. Similar manifestations of softening nonlinearities have been attributed to purely elastic nonlinear terms, coupling nonlinearities, hysteresis alone, or a combination of these effects by various authors. In order to develop a unified nonlinear nonconservative framework with two-way coupling, the present work investigates the nonlinear dynamic behavior of a bimorph piezoelectric cantilever under low to moderately high mechanical and electrical excitation levels in energy harvesting, sensing, and actuation. The highest voltage levels, for near resonance investigation, are well below the coercive field. A distributed parameter electroelastic model is developed by accounting for softening and dissipative nonlinearities to analyze the primary resonance of a soft (e.g., PZT-5A, PZT-5H) piezoelectric cantilever for the fundamental bending mode using the method of harmonic balance. Excellent agreement between the model and experimental investigation is found, providing evidence that quadratic stiffness, damping, and electromechanical coupling effects accurately model predominantly observed nonlinear effects in geometrically linear vibration of piezoelectric cantilever beams. The backbone curves of both energy harvesting and actuation frequency responses for a PZT-5A cantilever are experimentally found to be dominantly of first order and specifically governed by ferroelastic quadratic softening for a broad range of mechanical and electrical excitation levels. Cubic and higher-order nonlinearities become effective only near the physical limits of the brittle and stiff (geometrically linear) bimorph cantilever when excited near resonance.
Similar content being viewed by others
Notes
A set of actuation experiments conducted in vacuum (not reported here) yield almost identical frequency response curves, suggesting that the quadratic dissipation is an internal nonlinear loss rather than due to air damping.
References
Maugin, G.A.: Nonlinear Electromechanical Effects and Applications, vol. 1. World Scientific, Singapore (1985)
Tiersten, H.F.: Electroelastic equations for electroded thin plates subject to large driving voltages. J. Appl. Phys. 74, 3389–3393 (1993)
Aurelle, N., Guyomar, D., Richard, C., Gonnard, P., Eyraud, L.: Nonlinear behavior of an ultrasonic transducer. Ultrasonics 34, 187–191 (1996)
Guyomar, D., Aurelle, N., Eyraud, L.: Piezoelectric ceramics nonlinear behavior. Application to langevin transducer. J. De Physique III(7), 1197–1208 1997)
Abdelkefi, A., Nayfeh, A.H., Hajj, M.R.: Effects of nonlinear piezoelectric coupling on energy harvesters under direct excitation. Nonlinear Dyn. 67, 1221–1232 (2011)
Abdelkefi, A., Nayfeh, A.H., Hajj, M.R.: Global nonlinear distributed-parameter model of parametrically excited piezoelectric energy harvesters. Nonlinear Dyn. 67, 1147–1160 (2011)
Wang, Q.M., Zhang, Q.M., Xu, B.M., Liu, R.B., Cross, L.E.: Nonlinear piezoelectric behavior of ceramic bending mode actuators under strong electric fields. J. Appl. Phys. 86, 3352–3360 (1999)
Albareda, A., Gonnard, P., Perrin, V., Briot, R., Guyomar, D.: Characterization of the mechanical nonlinear behavior of piezoelectric ceramics. IEEE Trans. Ultrason. Ferroelectr. Freq. Control 47, 844–853 (2000)
Priya, S., Viehland, D., Carazo, A.V., Ryu, J., Uchino, K.: High-power resonant measurements of piezoelectric materials: importance of elastic nonlinearities. J. Appl. Phys. 90, 1469–1479 (2001)
Wolf, K., Gottlieb, O.: Nonlinear Dynamics of a Cantilever Beam Actuated by Piezoelectric Layers in Symmetric and Assymetric Configuration. Technion-Israel Institute of Technology, Technical Report ETR-2001-02 (2001)
Usher, T., Sim, A.: Nonlinear dynamics of piezoelectric high displacement actuators in cantilever mode. J. Appl. Phys. 98, 64102 (2005)
Von Wagner, U., Hagedorn, P.: Piezo-beam systems subjected to weak electric field: experiments and modelling of non-linearities. J. Sound Vib. 256, 861–872 (2002)
Mahmoodi, S.N., Jalili, N., Daqaq, M.F.: Modeling, nonlinear dynamics, and identification of a piezoelectrically actuated microcantilever sensor. IEEE-ASME Trans. Mechatron. 13, 58–65 (2008)
Hu, Y., Xue, H., Yang, J., Jiang, Q.: Nonlinear behavior of a piezoelectric power harvester near resonance. IEEE Trans. Ultrason. Ferroelectr. Freq. Control 53, 1387–1391 (2006)
Stanton, S.C., Erturk, A., Mann, B.P., Inman, D.J.: Nonlinear piezoelectricity in electroelastic energy harvesters: modeling and experimental identification. J. Appl. Phys. 108, 74903 (2010)
Stanton, S.C., Erturk, A., Mann, B.P., Inman, D.J.: Resonant manifestation of intrinsic nonlinearity within electroelastic micropower generators. Appl. Phys. Lett. 97, 254101 (2010)
Nayfeh, A.H., Mook, D.T.: Nonlinear Oscillations. Wiley, New York (2008)
Stanton, S.C., Erturk, A., Mann, B.P., Dowell, E.H., Inman, D.J.: Nonlinear nonconservative behavior and modeling of piezoelectric energy harvesters including proof mass effects. J. Intell. Mater. Syst. Struct. 23, 183–199 (2012)
Goldschmidtboeing, F., Eichhorn, C., Wischke, M., Kroener, M., Woias, P.: The influence of ferroelastic hysteresis on mechanically excited PZT cantilever beams. In: Proceedings of the 11th International Workshop on Micro and Nanotechnology for Power Generation and Energy Conversion Applications, pp. 114–117 (2011)
Kamlah, M.: Ferroelectric and ferroelastic piezoceramics-modeling of electromechanical hysteresis phenomena. Contin. Mech. Thermodyn. 13, 219–268 (2001)
Damjanovic, D.: Hysteresis in piezoelectric and ferroelectric materials. Sci. Hysteresis 3, 337–465 (2005)
Smith, R.C., Seelecke, S., Dapino, M., Ounaies, Z.: A unified framework for modeling hysteresis in ferroic materials. J. Mech. Phys. Solids 54, 46–85 (2006)
Crandall, S.H.: Dynamics of Mechanical and Electromechanical Systems. McGraw-Hill, New York (1968)
Erturk, A., Inman, D.J.: Piezoelectric Energy Harvesting. Wiley, New York (2011)
Dutoit, N.E., Wardle, B.L.: Experimental verification of models for microfabricated piezoelectric vibration energy harvesters. AIAA J. 45, 1126–1137 (2007)
Erturk, A., Inman, D.J.: An experimentally validated bimorph cantilever model for piezoelectric energy harvesting from base excitations. Smart Mater. Struct. 18, 025009 (2009)
Acknowledgments
This work was supported in part by the National Science Foundation under Grant CMMI-1254262.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Leadenham, S., Erturk, A. Unified nonlinear electroelastic dynamics of a bimorph piezoelectric cantilever for energy harvesting, sensing, and actuation. Nonlinear Dyn 79, 1727–1743 (2015). https://doi.org/10.1007/s11071-014-1770-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11071-014-1770-x