Skip to main content
SpringerLink
Log in

Wettability Alteration in Carbonate Rocks by Implementing New Derived Natural Surfactant: Enhanced Oil Recovery Applications

  • Published:
Transport in Porous Media Aims and scope Submit manuscript

Abstract

One of the robust and high-performance EOR methods which use chemical agents is chemical flooding. Environmental impacts, surfactant cost, and oil price are the three main parameters that affect on the robustness of the surfactant flooding in oil reservoirs. Interfacial tension reduction and wettability alteration of the reservoir rocks are the two main mechanisms of the oil recovery via employing surfactant flooding. The preliminary study about adsorption and environmental impacts of the new natural-based surfactant which derived from roots of Glycyrrhiza Glabra was investigated systematically by the authors and proved the ability of the aforementioned surfactant for EOR goals. Thanks to this point that throughout the current study, core displacement tests and qualitative and quantitative wettability experiments were carried out to specify performance of the above-mentioned natural surfactant in oil recovery. For wettability alteration measurements, contact angle measurement as a quantitative method, and floatation and two-phase separation experiments as qualitative methods were utilized. In addition, three commonly industrial surfactants were implemented throughout the wettability alteration experiments to contrast performance of the used surfactants. Thanks to the outcomes obtained from qualitative and quantitative wettability alteration experiments, and the surfactant suggested in this study could change wettability of carbonate rock from strongly oil-wet toward water-wet state. In addition, based on the core displacement experiments, it is robust, cheap, and high performance in comparison with other conventional industrial surfactants for surfactant flooding purposes. There is a hypothesis that the addressed raw surfactant can be utilized in chemical flooding of oil reservoirs owing to very low cost and availability around the world compared to other currently implemented surfactants.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15
Fig. 16
Fig. 17
Fig. 18
Fig. 19
Fig. 20
Fig. 21
Fig. 22
Fig. 23
Fig. 24
Fig. 25
Fig. 26

Similar content being viewed by others

References

  • Ahmadi, M.A., Shadizadeh, S.R.: Adsorption of novel nonionic surfactant and particles mixture in carbonates: enhanced oil recovery implication. Energy Fuels 26, 4655–4663 (2012)

  • Ahmadi, M.A., Zendehboudi, S., James, L.: Nonionic surfactant for enhanced oil recovery from carbonates: adsorption kinetics and equilibrium. J. Ind. Eng. Chem. Res. 51(29), 9894–9905 (2012)

    Article  Google Scholar 

  • Ahmadi, M.A., Shadizadeh, S.R.: Experimental investigation of adsorption of a new nonionic surfactant on carbonate minerals. J. Fuel 104, 462–467 (2013a)

    Article  Google Scholar 

  • Ahmadi, M.A., Shadizadeh, S.R.: Induced effect of adding nano silica on adsorption of a natural surfactant onto sandstone rock: experimental and theoretical study. J. Pet. Sci. Eng. 112, 239–247 (2013b)

    Article  Google Scholar 

  • Anderson, W.: Wettability literature survey: Part 2. Wettability measurement. J. Pet. Technol. 38(11), 1246–1262 (1986)

    Article  Google Scholar 

  • Babadagli, T.: Evaluation of the critical parameters in oil recovery from fractured chalks by surfactant injection. J. Pet. Sci. Eng. 54(1–2), 43–54 (2006)

    Article  Google Scholar 

  • Chen, I.C., Akbulut, M.: Nanoscale dynamics of heavy oil recovery using surfactant floods. Energy Fuels 26, 7176–7182 (2012)

    Article  Google Scholar 

  • Dandekar, A.Y.: Petroleum Reservoir Rock and Fluid Properties. CRC/Taylor & Francis, Boca Raton (2006)

    Google Scholar 

  • Donaldson, E.C., Chilingar, G.V., Yen, T.F.: Enhanced Oil Recovery: Fundamentals and Analysis. Elsevier, Amsterdam (1985)

    Google Scholar 

  • Earlougher, R.C., Oneal, J.E., Surkalo, H.: Micellar solution flooding—field test results and process improvements. J. Can. Pet. Technol. 15(1), 52–59 (1976)

    Article  Google Scholar 

  • Ehrlich, R., Wygal, R.: Interrelation of crude oil and rock properties with the recovery of oil by caustic waterflooding. SPE J. 17(4), 263–270 (1977)

    Article  Google Scholar 

  • French, M.S., Keys, G.W., Stegemei, G.L., Ueber, R.C., Abrams, A., Hill, H.J.: Field test of an aqueous surfactant system for oil recovery, Benton Field, Illinois. J. Pet. Technol. 25, 195–204 (1973)

    Article  Google Scholar 

  • Gogarty, W.B., Surkalo, H.: A field test of micellar solution flooding. J. Pet. Technol. 24, 1161 (1972)

    Article  Google Scholar 

  • Hill, H.J., Reisberg, J., Stegemei, G.L.: Aqueous surfactant systems for oil recovery. J. Pet. Technol. 25, 186–194 (1973)

    Article  Google Scholar 

  • Hirasaki, G., Zhang, D.L.: Surface chemistry of oil recovery from fractured oil-wet, carbonate formations. SPE J. 9(2), 151–162 (2004)

    Article  Google Scholar 

  • Hirasaki, G.J., Miller, C.A., Puerto, M.: Recent advances in surfactant EOR. SPE J. 16(4), 889–907 (2011)

    Article  Google Scholar 

  • Islam, M.R.: Emerging technologies in enhanced oil recovery. Energy Sources 21(1–2), 97–111 (1999)

    Article  Google Scholar 

  • Jarrahian, Kh, Seiedi, O., Sheykhan, M., Vafaie Sefti, M., Ayatollahi, Sh: Wettability alteration of carbonate rocks by surfactants: a mechanistic study. Colloids Surf. A 410, 1–10 (2012)

    Article  Google Scholar 

  • Kjellim, M., Johansson, I.: Surfactants from Renewable Resources. Wiley, Chichester (2010)

    Book  Google Scholar 

  • Kumar, K., Dao, E., Mohanty, K.K.: Heavy-oil recovery by in-situ emulsion formation. SPE J. 17(2), 137–145 (2012)

    Article  Google Scholar 

  • Lake, L.W., Pope, G.A.: Status of micellar-polymer field tests. Pet. Eng. 51, 38–60 (1979)

    Google Scholar 

  • Lake, L.W.: Enhanced Oil Recovery. Prentice Hall, Englewood Cliffs (1989)

    Google Scholar 

  • Lake, L.W., Venuto, P.B.: A niche for enhanced oil recovery in the 1990s. Oil Gas J. 88(17), 62–67 (1990)

    Google Scholar 

  • Liu, Q., Dong, M.Z., Ma, S.Z., Tu, Y.: Surfactant enhanced alkaline flooding for Western Canadian heavy oil recovery. Colloids Surf. A 293(1–3), 63–71 (2007)

    Article  Google Scholar 

  • Morrow, N.R.: Wettability and its effect on oil recovery. J. Pet. Technol. 42(12), 1476–1484 (1990)

    Article  Google Scholar 

  • Myers, D.: Surfaces, Interfaces, and Colloids. Wiley, New York (1999)

    Book  Google Scholar 

  • Pope, G.A.: The application of fractional flow theory to enhanced oil recovery. Soc. Pet. Eng. J. 20(3), 191–205 (1980)

    Article  Google Scholar 

  • Pursley, S.A., Healy, R.N., Sandvik, E.I.: A field test of surfactant flooding, Loudon, Illinois. J. Pet. Technol. 25, 793–802 (1973)

    Article  Google Scholar 

  • Pursley, S.A., Graham, H.L.: Borregos field surfactant pilot test. J. Pet. Technol. 27, 695–700 (1975)

    Article  Google Scholar 

  • Ravari, R.R., Strand, S., Austad, T.: Combined surfactant-enhanced gravity drainage (SEGD) of oil and the wettability alteration in carbonates: the effect of rock permeability and interfacial tension (IFT). Energy Fuels 25(5), 2083–2088 (2011)

    Article  Google Scholar 

  • Salehi, M.: Enhancing the spontaneous imbibition process in naturally fractured reservoirs through wettability alteration using surfactants: mechanistic study and feasibility of using biosurfactants produced from agriculture waste streams. PhD thesis, The University of Kansas (2009)

  • Schramm, L.L.: Surfactants: Fundamentals and Applications in the Petroleum Industry. Cambridge University Press, Cambridge (2000)

    Book  Google Scholar 

  • Shen, P.P., Zhu, B., Li, X.B., Wu, Y.S.: An experimental study of the influence of interfacial tension on water–oil two-phase relative permeability. Transp. Porous Media 85(2), 505–520 (2010)

    Article  Google Scholar 

  • Sheng, J.J.: Optimum phase type and optimum salinity profile in surfactant flooding. J. Pet. Sci. Eng. 75(1–2), 143–153 (2010)

    Article  Google Scholar 

  • Sheng, J.: Modern Chemical Enhanced Oil Recovery: Theory and Practice. Gulf Professional Publishers, Amsterdam (2011)

    Google Scholar 

  • Standnes, D.C., Austad, T.: Wettability alteration in chalk: 1. Preparation of core material and oil properties. J. Pet. Sci. Eng. 28(3), 111–121 (2000a)

    Article  Google Scholar 

  • Standnes, D.C., Austad, T.: Wettability alteration in chalk: 2. Mechanism for wettability alteration from oil-wet to water-wet using surfactants. J. Pet. Sci. Eng. 28(3), 123–143 (2000b)

    Article  Google Scholar 

  • Taber, J.: Research on enhanced oil-recovery—past, present and future. J. Pure Appl. Chem. 52(5), 1323–1347 (1980)

    Article  Google Scholar 

  • Thomas, S.: Enhanced oil recovery—an overview. Oil Gas Sci. Technol. Rev. D. IFP Energ. Nouv. 63(1), 9–19 (2008)

    Article  Google Scholar 

  • Wu, W.X., Pan, J.H., Guo, M.R.: Mechanisms of oil displacement by ASP-foam and its influencing factors. Pet. Sci. 7(1), 100–105 (2010)

    Article  Google Scholar 

  • Yu, Q., Jiang, H., Zhao, C.: Study of interfacial tension between oil and surfactant polymer flooding. Pet. Sci. Technol. 28(18), 1846–1854 (2010)

    Article  Google Scholar 

  • Zendehboudi, S., Ahmadi, M.A., Rajabzadeh, A.R., Mahinpey, N., Chatzis, I.: Experimental study on adsorption of a new surfactant onto carbonate reservoir samples—application to EOR. Can. J. Chem. Eng. 91(8), 1439–1449 (2013)

    Article  Google Scholar 

  • Zhang, H.Y., Dong, M.Z., Zhao, S.Q.: Which one is more important in chemical flooding for enhanced court heavy oil recovery, lowering interfacial tension or reducing water mobility? Energy Fuels 24, 1829–1836 (2010)

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Petroleum Engineering, Ahwaz Faculty of Petroleum Engineering, Petroleum University of Technology, Ahwaz, Iran

    Mohammad Ali Ahmadi & Morteza Galedarzadeh

  2. Department of Petroleum Engineering, Abadan Faculty of Petroleum Engineering, Petroleum University of Technology, Abadan, Iran

    Seyed Reza Shadizadeh

Authors
  1. Mohammad Ali Ahmadi
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Morteza Galedarzadeh
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Seyed Reza Shadizadeh
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Mohammad Ali Ahmadi.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Ahmadi, M.A., Galedarzadeh, M. & Shadizadeh, S.R. Wettability Alteration in Carbonate Rocks by Implementing New Derived Natural Surfactant: Enhanced Oil Recovery Applications. Transp Porous Med 106, 645–667 (2015). https://doi.org/10.1007/s11242-014-0418-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11242-014-0418-0

Keywords

Search

Navigation