Skip to main content
SpringerLink
Log in

Regeneration of adsorbents and recovery of heavy metals: a review

  • Review
  • Published:
International Journal of Environmental Science and Technology Aims and scope Submit manuscript

Abstract

In last a few decades, significant improvements were made in both efficiency and economy for removal of heavy metals and metalloid (arsenic) from water using adsorbents. But less attention was paid to recycling of used adsorbents and recovery of the heavy metals from the desorbing agents. For regeneration and reuse of adsorbents, various possible regenerating agents such as acids, alkalis and chelating agents (such as ethylene diamine tetraacetic acid) were used by many researchers with very limited success in some of the studies only up to a limited number of adsorption–desorption cycles. Only a few of the reported studies were focused on recovery of adsorbed (from saturated adsorbents) and desorbed metals (from regenerating agents). Though the management of the used adsorbent and recovery of heavy metals is one of the most important aspects, but only a limited number of research works considered the fate of spent adsorbents before disposal. This review summarizes the removal efficiency of various adsorbents, desorption efficiency of various regenerating agents and recovery of the heavy metals from both saturated adsorbents and desorbing solvents used for regeneration. The study will help the scientific community working on adsorption studies to take up research initiatives required to address the feasible recovery methods of heavy metals from the used adsorbents, to study the possible reuse of the desorbing agents and to choose a suitable desorbing/regenerating agent for a particular adsorbent.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  • Ahmaruzzaman M, Gupta VK (2011) Rice husk and its ash as low-cost adsorbents in water and wastewater treatment. Ind Eng Chem Res 50(24):13589–13613

    Article  CAS  Google Scholar 

  • Ahmed FM (2001) An overview of arsenic removal technologies in Bangladesh and India. Technologies for arsenic removal from drinking water, Bangladesh University of Engineering and Technology (BUET) and United Nations University (UNU), pp 251–269. http://archive.unu.edu/env/Arsenic/Ahmed.pdf (July 27, 2012)

  • Ahmed MF (2005) Arsenic mitigation technologies in south and east Asia. In: Towards a more effective operational response, vol. 2, Technical Report No. 31303, Water and Sanitation Program-South Asia and the World Bank, pp 166–207

  • Ajmal M, Rao RAK, Anwar S, Ahmad J, Ahmad R (2003) Adsorption studies on rice husk: removal and recovery of Cd(II) from wastewater. Bioresour Technol 86:147–149

    Article  CAS  Google Scholar 

  • Ali I (2012) New generation adsorbents for water treatment. Chem Rev 112:5073–5091

    Article  CAS  Google Scholar 

  • Anirudhan TS, Unnithan MR (2007) Arsenic (V) removal from aqueous solutions using an anion exchanger derived from coconut coir pith and its recovery. Chemosphere 66:60–66

    Article  CAS  Google Scholar 

  • Bai RS, Abraham TE (2003) Studies on chromium(VI) adsorption-desorption using immobilized fungal biomass. Bioresour Technol 87:17–26

    Article  Google Scholar 

  • Bajpai S, Chaudhari M (1999) Removal of arsenic from ground water by manganese dioxide-coated sand. J Environ Eng 125:782–784

    Article  CAS  Google Scholar 

  • Baldwin DR, Marshal WJ (1999) Heavy metal poisoning and its laboratory investigation. Ann Clin Biochem 36:267–300

    Article  CAS  Google Scholar 

  • Benjamin MM, Sletten RS, Bailey RP, Bennett T (1996) Sorption and filtration of metals using iron oxide coated sand. Water Res 30:2609–2620

    Article  CAS  Google Scholar 

  • Bhatnagar A, Vilar VJP, Botelho CMS, Boaventura RAR (2010) Coconut-based biosorbents for water treatment: a review of the recent literature. Adv Colloid Interface Sci 160:1–15

    Article  CAS  Google Scholar 

  • Boricha AB, Bajaj HC, Ghosh PK, Jasra RV (2007) Recovery of palladium from palladium phthalocyanine complex adsorbed on silica. J Hydrometall 87:140–147

    Article  CAS  Google Scholar 

  • Chiou P, Tang W, Lin CJ, Chu HW, Ho TC (2009) Comparison of atmospheric aerosols between two sites over golden triangle of Texas. Int J Environ Res 3(2):253–270

    CAS  Google Scholar 

  • Choong TSY, Chuaha TG, Robiaha Y, Koaya FLG, Azni I (2007) Arsenic toxicity, health hazards and removal techniques from water: an overview. Desalination 217:139–166

    Article  CAS  Google Scholar 

  • Chuang CL, Fan M, Xu M, Brown RC, Sung S, Saha B, Huang CP (2005) Adsorption of arsenic (V) by activated carbon prepared from oat hulls. Chemosphere 61:478–483

    Article  CAS  Google Scholar 

  • Conceição FT, Navarro GRB, Silva AM (2013) Anthropogenic influences on Cd, Cr, Cu, Ni, Pb and Zn concentrations in soils and sediments in a watershed with sugar cane crops at São Paulo State, Brazil. Int J Environ Res 7(3):551–560

    Google Scholar 

  • Crini G (2005) Recent developments in polysaccharide-based materials used as adsorbents in wastewater treatment. Prog Polym Sci 30:38–70

    Article  CAS  Google Scholar 

  • Cui H, Li LY, Grace JR (2006) Exploration of remediation of acid rock drainage with clinoptilolite as sorbent in a slurry bubble column for both heavy metal capture and regeneration. Water Res 40:3359–3366

    Article  CAS  Google Scholar 

  • Das N (2010) Recovery of precious metals through biosorption: a review. Hydrometallurgy 103:180–189

    Article  CAS  Google Scholar 

  • Davis TA, Volesky B, Mucci A (2003) A review of the biochemistry of heavy metal biosorption by brown algae. Water Res 37:4311–4330

    Article  CAS  Google Scholar 

  • Deng L, Su Y, Su H, Wang X, Zhu X (2007) Sorption and desorption of lead(II) from wastewater by green algae Cladophora fascicularis. J Hazard Mater 143:220–225

    Article  CAS  Google Scholar 

  • Deng L, Zhu X, Su Y, Su H, Wang X (2008) Biosorption and desorption of Cd2+ from wastewater by dehydrated shreds of Cladophora fascicularis. Chin J Oceanol Limnol 26:45–49

    Article  CAS  Google Scholar 

  • Duarte AALS, Cardoso SJA, Alcada AJ (2009) Emerging and innovative techniques for arsenic removal applied to a small water supply system. Sustainability 1:1288–1304

    Article  CAS  Google Scholar 

  • Engelmann MD, Metz LA, Ballou NE (2006) Recovery of technetium adsorbed on charcoal. Radioanal Nucl Chem 268:201–204

    Article  CAS  Google Scholar 

  • Fu F, Wang Q (2011) Removal of heavy metal ions from wastewaters: a review. J Environ Manage 92:407–418

    Article  CAS  Google Scholar 

  • Giménez J, Martíneza M, Pabloa JD, Rovirab M, Duroc L (2007) Arsenic sorption onto natural hematite, magnetite, and goethite. J Hazard Mater 141:575–580

    Article  Google Scholar 

  • Gong R, Ding Y, Liu H, Chen Q, Liu Z (2005) Lead biosorption and desorption by intact and pretreated Spirulina maxima biomass. Chemosphere 58:125–130

    Article  CAS  Google Scholar 

  • Grassi M, Kaykioglu G, Belgiorno V, Lofrano G (2012) Removal of emerging contaminants from water and wastewater by adsorption process. Chapter 2, doi: 10.1007/978-94-007-3916-1_2

  • Gupta VK, Nayak A (2012) Cadmium removal and recovery from aqueous solutions by novel adsorbents prepared from orange peel and Fe2O3 nanoparticles. Chem Eng 180:81–90

    Article  CAS  Google Scholar 

  • Gupta VK, Rastogi A (2008) Sorption and desorption studies of chromium(VI) from nonviable cyanobacterium Nostoc muscorum biomass. J Hazard Mater 154:347–354

    Article  CAS  Google Scholar 

  • Gupta R, Khan PAS, Saxena RK, Mohapatra H (2000) Microbial biosorbents: meeting challenges of heavy metal pollution in aqueous solutions. Curr Sci 78(8):25

    Google Scholar 

  • Hang C, Li Q, Gao S, Shang JK (2012) As(III) and As(V) Adsorption by hydrous zirconium oxide nanoparticles synthesized by a hydrothermal process followed with heat treatment. Ind Eng Chem Res 51:353–361

    Article  CAS  Google Scholar 

  • Hu J, Shipley HJ (2012) Evaluation of desorption of Pb(II), Cu(II) and Zn(II) from titanium dioxide nanoparticles. Sci Total Environ 431:209–220

    Article  CAS  Google Scholar 

  • Hu J, Shipley HJ (2013) Regeneration of spent TiO2 nanoparticles for Pb(II), Cu(II), and Zn(II) removal. Environ Sci Pollut Res 20:5125–5137

    Article  CAS  Google Scholar 

  • Hu J, Chen G, Lo IMC (2005) Removal and recovery of Cr(VI) from wastewater by maghemite nanoparticles. Water Res 39:4528–4536

    Article  CAS  Google Scholar 

  • Huang CP, Fu PLK (1984) Treatment of arsenic (V) containing water by the activated carbon process. J Water Pollut Contl Fed 56(3):233–242

    CAS  Google Scholar 

  • Iqbal M, Saeed A, Akhtar N (2002) Petiolar felt sheath of palm: a new adsorbent for the removal of heavy metals from contaminated water. Bioresour Technol 81:151–153

    Article  CAS  Google Scholar 

  • Jain SK, Vasudevan P, Jha NK (1989) Removal of some heavy metals from polluted water by aquatic plants: studies on duckweed and water velvet. Biol Wastes 28:115–126

    Article  CAS  Google Scholar 

  • Jalali R, Ghafourian H, Asef Y, Davarpanah SJ, Sepeh S (2002) Removal and recovery of lead using nonliving biomass of marine algae. J Hazard Mat B 92:253–262

    Article  CAS  Google Scholar 

  • Jeon C, Park KH (2005) Adsorption and desorption characteristics of mercury(II) ions using aminated chitosan bead. Water Res 393:938–3944

    Google Scholar 

  • Jeon C, Park JY, Yoo YJ (2002) Characteristics of metal removal using carboxylated alginic acid”. Water Res 36:1814–1824

    Article  CAS  Google Scholar 

  • Kamala CT, Chu KH, Char NS et al (2005) Removal of arsenic(III) from aqueous solutions using fresh and immobilized plant biomass. Water Res 39:2815–2826

    Article  CAS  Google Scholar 

  • Katsou E, Malamis S, Tzanoudaki M, Haralambous KJ, Loizidou M (2011) Regeneration of natural zeolite polluted by lead and zinc in wastewater treatment systems. J Hazard Mater 189:773–786

    Article  CAS  Google Scholar 

  • Kordialik-Bogacka E (2011) Cadmium and lead recovery from yeast biomass. Cent Eur J Chem 9:320–325

    Article  CAS  Google Scholar 

  • Kuang M, Yang G, Chen W, Zhang Z (2008) Study on mercury desorption from silver-loaded activated carbon fibre and activated carbon fibre. Fuel Chem Technol 36:468–473

    Article  CAS  Google Scholar 

  • Kyzas GZ (2012) Commercial coffee wastes as materials for adsorption of heavy metals from aqueous solutions. Materials 5(10):1826–1840

    Article  CAS  Google Scholar 

  • Lin TF, Wu JK (2001) Adsorption of arsenite and arsenate within activated alumina grains: equilibrium and kinetics. Water Res 35(8):2049–2057

    Article  CAS  Google Scholar 

  • Liu M, Deng Y, Zhan H, Zhang X (2002) Adsorption and desorption of copper(II) from solutions on new spherical cellulose adsorbent. J Appl Poly Sci 84:478–485

    Article  CAS  Google Scholar 

  • Maeda S, Ohki A, Tsurusaki Y, Takeshita T (1990) Selective adsorption of arsenic (V) ion by use of iron(III) hydroxide-loaded coral limestone. Sep Sci Technol 25(5):547–555

    Article  CAS  Google Scholar 

  • Mamatha M, Aravinda HB, Puttaiah ET, Manjappa S (2013) Adsorbent from Pongamia Pinnata tree bark for zinc adsorption. Int J Sci Eng Technol 2(1):22–25

    Google Scholar 

  • Mandal BK, Sujuki KJ (2002) Arsenic round the world: a review. Talanta 58:201–235

    Article  CAS  Google Scholar 

  • Manju GN, Raji C, Anirudhan TS (1998) Evaluation of coconut husk carbon for the removal of arsenic from water. J Water Res 32:3062–3070

    Article  CAS  Google Scholar 

  • Menoud P, Schmidt V, Meyer T, Renken A (1995) Selective separation and recovery of heavy metals from industrial wastewater. Proceedings of the international congress on recovery recycling reintegration (R’95), Geneva, 3, pp. 378–384

  • Menoud P, Cavin L, Renken A (2000) New regeneration process of heavy-metal-loaded chelating resins. Chem Eng Technol 23:5

    Article  Google Scholar 

  • Moaref S, Sekhavatjou MS, Hosseini Alhashemi A (2014) Determination of trace elements concentration in wet and dry atmospheric deposition and surface soil in the largest industrial city, southwest of Iran. Int J Environ Res 8(2):335–346

    CAS  Google Scholar 

  • Mohan D, Pittman JCU (2007) Arsenic removal from water/wastewater using adsorbents-A critical review. Int J Miner Process 92:42–48

    Google Scholar 

  • Motsi T (2010) Remediation of acid mine drainage using natural zeolite. School of Chemical Engineering, the University of Birmingham, United Kingdom

  • Motsi T, Rowson NA, Simmons MJH (2009) Adsorption of heavy metals from acid mine drainage by natural zeolite. Int J Miner Process 92:42–48

    Article  CAS  Google Scholar 

  • Murcott S (1999) Appropriate remediation technologies for arsenic-contaminated wells in Bangladesh. Presented at arsenic in Bangladesh ground water. Wagner College, Staten Island, New York, pp 27–28

  • Namasivayam C, Kadirvelu K (1999) Uptake of mercury(II) from wastewater by activated carbon from unwanted agricultural solid by-product: coirpith. Carbon 37:79–84

    Article  CAS  Google Scholar 

  • Nayak D, Lahiri S (2006) Biosorption of toxic, heavy, no-carrier-added radionuclides by calcium alginate beads. J Radioanal Nucl Chem 267(1):59–65

    Article  CAS  Google Scholar 

  • O’Connell DW, Birkinshawb C, O’Dwyer TF (2008) Heavy metal adsorbents prepared from the modification of cellulose: a review. Bioresour Technol 99:6709–6724

    Article  Google Scholar 

  • Okoniewska E, Lach J, Kacprzak M, Neczaj E (2008) The trial of regeneration of used impregnated activated carbons after manganese sorption. Desalination 223:256–263

    Article  CAS  Google Scholar 

  • Praveena SM, Ahmed A, Radojevic M, Abdullah MH, Aris AZ (2008) Heavy metals in mangrove surface sediment of Mengkabong lagoon, Sabah: multivariate and geo-accumulation index approaches. Int J Environ Res 2(2):139–148

    CAS  Google Scholar 

  • Ranjan D, Talat M, Hasan SH (2009) Biosorption of arsenic from aqueous solution using agricultural residue ‘rice polish. J Hazard Mater 166:1050–1059

    Article  CAS  Google Scholar 

  • Saeed A, Akhterb MW, Iqbal M (2005) Removal and recovery of heavy metals from aqueous solution using papaya wood as a new biosorbent. Sep Purif Technol 45:25–31

    Article  CAS  Google Scholar 

  • Samadder SR (2011) Impact of arsenic pollution on spatial distribution of human development index (HDI). KSCE J Civil Eng 15(6):975–982

    Article  Google Scholar 

  • Singh TS, Pant KK (2004) Equilibrium, kinetics and thermodynamic studies for adsorption of As(III) on activated alumina. Sep Purif Technol 36:139–147

    Article  CAS  Google Scholar 

  • Singh DB, Tiwary RK, Tewary BK (2002) Feldspar for the treatment of As(III) contaminated water. Water Qual Res J Can 37(4):757–771

    CAS  Google Scholar 

  • Smedley PL, Kinniburg DG (2002) A review of the source, behaviour and distribution of arsenic in natural waters. Appl Geochem 17:517–568

    Article  CAS  Google Scholar 

  • Srivastava S, Goyal P (2010) Reusability of biomaterial: a cost effective approach. Environ Sci Eng 93–96

  • Stirk WA, Staden JV (2002) Desorption of cadmium and the reuse of brown seaweed derived products as biosorbents. Bot Mar 45:9–16

    Article  CAS  Google Scholar 

  • Sud D, Mahajan G, Kaur MP (2008) Agricultural waste material as potential adsorbent for sequestering heavy metal ions from aqueous solutions: a review. Bioresour Technol 99:6017–6027

    Article  CAS  Google Scholar 

  • Taghinia Hejabi A, Basavarajappa HT, Qaid Saeed AM (2010) Heavy metal pollution in Kabini river sediments. Int J Environ Res 4(4):629–636

    CAS  Google Scholar 

  • Tan IAW, Ahmad AL, Hameed BH (2008) Preparation of activated carbon from coconut husk: optimization study on removal of 2,4,6- trichlorophenol using response surface methodology. J Hazard Mater 153:709–717

    Article  CAS  Google Scholar 

  • Thirunavukkarasu OS, Viraraghavan T, Subramanian KS (2003) Arsenic removal from drinking water using iron oxide coated sand. Water Air Soil Pollut 142:95–111

    Article  CAS  Google Scholar 

  • Tian Y, Wu M, Lin X, Huang P, Huang Y (2011) Synthesis of magnetic wheat straw for arsenic adsorption. J Hazard Mater 193:10–16

    Article  CAS  Google Scholar 

  • Tseng JY, Chang CY, Chang CF et al (2009) Kinetics and equilibrium of desorption removal of copper from magnetic polymer adsorbent. J Hazard Mater 171:370–377

    Article  CAS  Google Scholar 

  • Tzou Y, Wang S, Hsu L, Chan R, Lin C (2007) Deintercalation of Li/Al LDH and its application to recover adsorbed chromate from used adsorbent. J Appl Clay Sci 37:107–114

    Article  CAS  Google Scholar 

  • Vu KB, Kaminski MD, Nunez L (2003) Review of arsenic removal technologies for contaminated groundwaters. Chemical Engineering Division, ANL-CMT-03/2, Argonne National Laboratory, Argonne, Illinois 60439, The University of Chicago

  • Wambu EW, Muthakia GK, Shiundu PM, Thiongo KJ (2009) Kinetics of copper desorption from regenerated spent bleaching earth. Am Eurasian J Sci Res 4:317–323

    CAS  Google Scholar 

  • Wasay SA, Haron MJ, Uchiumi A, Tokunaga S (1996a) Removal of arsenite and arsenate ions from aqueous solution by basic yttrium carbonate. Water Res 30(5):1143–1148

    Article  CAS  Google Scholar 

  • Wasay SA, Haron MJ, Tokunaga S (1996b) Adsorption of fluoride, phosphate, and arsenate ions on lanthanum-impregnated silica gel. Water Environ Res 68(3):295–300(6)

  • Wu Y, Wen Y, Zhou J, Cao J, Jin Y, Wu Y (2013) Comparative and competitive adsorption of Cr(VI), As(III), and Ni(II) onto coconut charcoal. Environ Sci Pollut Res 20:2210–2219

    Article  CAS  Google Scholar 

  • Xu YH, Nakajima T, Ohki A (2002) Adsorption and removal of arsenic(V) from drinking water by aluminum-loaded Shirasu-zeolite. J Hazard Mater B92:275–287

    Article  Google Scholar 

  • Xu W, Li LY, Grace JR (2012) Regeneration of natural bear river clinoptilolite sorbents used to remove Zn from acid mine drainage in a slurry bubble column. J Appl Clay Sci 55:83–87

    Article  CAS  Google Scholar 

  • Zelmanov G, Semiat R (2011) Iron Fe(III) oxide/hydroxide nanoparticles-based agglomerates suspension as adsorbent for chromium Cr(IV) removal from water and recovery. J Sep Purif Technol 80:330–337

    Article  CAS  Google Scholar 

  • Zhang L, Liu N, Yang L, Lin Q (2009) Sorption behavior of nano-TiO2 for the removal of selenium ions from aqueous solution. J Hazard Mater 170:1197–1203

    Article  CAS  Google Scholar 

  • Zhou Y, Haynes RJ (2012) A Comparison of Water Treatment Sludge and Red Mud as Adsorbents of As and Se in Aqueous Solution and Their Capacity for Desorption and Regeneration. Water Air Soil Pollut 223:5563–5573

    Article  CAS  Google Scholar 

  • Zhou Y, Hynes RJ (2011) A comparison of inorganic solid wastes as adsorbents of heavy metal cations in aqueous solution and their capacity for desorption and regeneration. Water Air Soil Pollut 218:457–470

    Article  CAS  Google Scholar 

  • Zhu H, Jia Y, Wu X, Wang H (2009) Removal of arsenic from water by supported nano zero-valent iron on activated carbon. J Hazard Mater 172:1591–1596

    Article  CAS  Google Scholar 

Download references

Acknowledgments

The authors acknowledge the support provided by the Department of Environmental Science and Engineering, Indian School of Mines, Dhanbad, for carrying out the research work.

Author information

Authors and Affiliations

  1. Department of Environmental Science and Engineering, Indian School of Mines, Dhanbad, 826004, India

    S. Lata, P. K. Singh & S. R. Samadder

Authors
  1. S. Lata
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. P. K. Singh
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. S. R. Samadder
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to S. R. Samadder.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Lata, S., Singh, P.K. & Samadder, S.R. Regeneration of adsorbents and recovery of heavy metals: a review. Int. J. Environ. Sci. Technol. 12, 1461–1478 (2015). https://doi.org/10.1007/s13762-014-0714-9

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13762-014-0714-9

Keywords

Search

Navigation