Abstract
Objective
To examine the correlation between airborne ethylene glycol dimethyl ether (EGdiME) exposures and the urinary methoxyacetic acid (MAA) and to approach the issue of a permissible exposure limit for EGdiME.
Methods
The survey was conducted on Thursday. Workers occupationally exposed to EGdiME, as well as nonexposed controls, were studied in combination with one of the authors, who was coincidentally exposed to EGdiME while carrying out the study. Air levels of EGdiME were determined by personal sampling on passive gas tubes. Urine was collected from nine control subjects and ten workers immediately before and after the shift, and from one of the authors at intervals during 12 h. The analyses of EGdiME in air and MAA in urine were performed by gas chromatography with flame ionization detection.
Results
The time-weighted average (TWA) air levels of EGdiME ranged from 0.7 to 10.5 ppm during 8 h work shifts. The urinary levels of MAA in one of the authors increased continuously during exposure and after the end of exposure. The levels of urinary MAA in the exposed workers were significantly higher than those in the control subjects. On the other hand, the postshift values were higher than the preshift values in the exposed workers, but the difference was not significant. A linear correlation was found between the TWA air levels of EGdiME and creatinine-adjusted MAA levels in urine collected at the end of the shift (r = 0.933; P < 0.0001). According to our equation, a linear extrapolation to the biological limit value recommended by Shih et al. (1999) of 40 mg MAA/g crea indicated an average inhalation exposure to EGdiME over the workweek of 12 ppm.
Conclusions
These results indicate that the determination of MAA in urine is suitable for use in the biological monitoring of EGdiME exposure.
This is a preview of subscription content, log in via an institution to check access.
References
ACGIH (2005) Threshold limit values for chemical substances and physical agents and biological exposure indices. ACGIH, Cincinnati, OH
Cook RR, Bodner KM, Kolesar RC, Vanpeenen PFD, Dickson GS, Flanagan K (1982) A cross-sectional study of ethylene glycol monomethyl ether process employees. Arch Environ Health 36:346–351
Cullen MR, Rado T, Waldron JA, Sparer J, Welch LS (1983) Bone marrow injury in lithographers exposed to glycol ethers and organic solvents used in multicolor offset and ultraviolet curing printing processes. Arch Environ Health 38:347–354
DFG (2005) Maximum concentrations and biological tolerance values at the workplace Wiley-VCH, Weinheim
Foster PM, Lloyd SC, Blackburn DM (1987) Comparison of the in vivo and in vitro testicular effects produced by methoxy-, ethoxy- and n-butoxy acetic acids in the rat. Toxicology 43:17–30
Groeseneken D, Veulemas H, Masschelein R, Van Vlem E (1989) Experimental human exposure to ethylene glycol monomethyl ether. Int Arch Occup Environ Health 61:243–247
Hardin BD, Eisenmann CJ (1987) Relative potency of four ethylene glycol ethers for induction of paw malformations in the CD-1 mouse. Teratology 35:321–328
Japan Society for Occupational Health (JSOH) (2005) Recommendation of occupational exposure limits (2005–2006). J Occup Health 47:354–370
Leonhardt DE, Coleman LW, Bradshaw WS (1991) Perinatal toxicity of ethylene glycol dimethyl ether in the rat. Reprod Toxicol 5:157–162
Rawlings SJ, Shuker DE, Webb M, Brown NA (1985) The teratogenic potential of alkoxy acids in post-implantation rat embryo culture: structure-activity relationships. Toxicol Lett 28:49–58
Sakai T, Araki T, Masuyama Y (1993) Determination of urinary alkoxyacetic acids by a rapid and simple method for biological monitoring of workers exposed to glycol ethers and their acetates. Int Arch Occup Environ health 64:495–498
Shih TS, Liou SH, Chen CY, Chou JS (1999) Correlation between urinary 2-methoxy acetic acid and exposure of 2-methoxy ethanol. Occup Environ Med 56:674–678
Shih TS, Hsieh AT, Liao GD, Chen YH, Liou SH (2000) Haematological and spermatotoxic effects of ethylene glycol monomethyl ether in copper clad laminate factories. Occup Environ Med 57:348–352
Shih TS, Liou SH, Chen CY, Smith TJ (2001) Urinary 2-methoxy acetic acid accumulation in response to 2-methoxy ethanol exposure. Arch Environ Health 56:20–24
Shih TS, Hsieh AT, Chen YH, Liao GD, Chen CY, Chou JS, Liou SH (2003) Follow up study of haematological effects in workers exposed to 2-methoxyethanol. Occup Environ Med 60:130–135
Uemura K (1980) The teratogenic effects of ethylene glycol dimethyl ether on mouse. Acta Obstet Gynaecol Jpn 32:113
Welch LS, Cullen MR (1988) Effect of exposure to ethylene glycol ethers on shipyard painters: III Hematologic effects. Am J Ind Med 14:527–536
Yokota K, Ikeda N, Johyama Y, Michitsuji H (2005) Urinary methoxyacetic acid as an indicator of occupational exposure to ethylene glycol dimethyl ether. Int Arch Occup Environ Health 78:650–654
Acknowledgments
We thank the staff and personnel of the company involved and the company health service for generous cooperation.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Yokota, K., Ueno, H., Ikeda, N. et al. Correlation between urinary methoxyacetic acid and exposure of ethylene glycol dimethyl ether in a lithium battery plant. Int Arch Occup Environ Health 81, 123–126 (2007). https://doi.org/10.1007/s00420-007-0198-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00420-007-0198-8