Skip to main content
Log in

Solute Crystallization in Frozen Systems–Use of Synchrotron Radiation to Improve Sensitivity

  • Research Paper
  • Published:
Pharmaceutical Research Aims and scope Submit manuscript

Abstract

Purpose

To demonstrate the sensitivity of low temperature synchrotron X-ray diffractometry (SXRD) for detecting solute crystallization in frozen sodium phosphate buffer solutions. To determine the effect of annealing on solute crystallization in frozen solutions.

Materials and Methods

Sodium phosphate buffer solutions, at initial buffer concentrations ranging from 1 to 100 mM (pH 7.4) were cooled to −50°C. The crystallization of disodium hydrogen phosphate dodecahydrate (Na2HPO4 •12H2O) was monitored using a laboratory as well as a synchrotron source. At selected concentrations, the effect of annealing (at −20°C) was investigated.

Results

With the laboratory source, solute crystallization, based on the appearance of one diagnostic peak with a d-spacing of 5.4 Å, was evident only when the initial buffer concentration was at least 50 mM. In contrast, using SXRD, crystallization was detected at initial buffer concentrations down to 1 mM. In addition, the use of a high-resolution 2D detector enabled the visualization of numerous diffraction rings of the crystalline solute. At both 10 and 100 mM buffer concentration, there was no increase in solute crystallization due to annealing.

Conclusion

By using synchrotron radiation, solute crystallization was detected with substantially increased sensitivity, making the technique useful for freeze-drying cycles of practical and commercial importance. Since numerous peaks of the crystalline solute appeared, the technique has potential utility in complex, multi-component systems.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5

Similar content being viewed by others

References

  1. X. Tang and M. J. Pikal. Design of freeze-drying processes for pharmaceuticals: practical advice. Pharm. Res. 21:191–200 (2004).

    Article  PubMed  CAS  Google Scholar 

  2. L. A. Trissel. Handbook of Injectable Drugs. ASHP, Bethesda, Maryland, 1994.

    Google Scholar 

  3. T. W. Randolph. Phase separation of excipients during lyophilization: effects on protein stability. J. Pharm. Sci. 86:1198–1202 (1997).

    Article  PubMed  CAS  Google Scholar 

  4. M. J. Pikal. Freeze Drying. Encyclopedia of Pharmaceutical Technology, Marcel Dekker, Inc. p.1299–1326, (2002).

  5. E. Y. Shalaev, F. Franks, and P. Echlin. Crystalline and amorphous phases in the ternary system water-sucrose-sodium chloride. J. Phys. Chem. 100:1144–1152 (1996).

    Article  CAS  Google Scholar 

  6. E. Y. Shalaev. The impact of buffer on processing and stability of freeze-dried dosage forms, part 1: solution freezing behavior. American Pharm. Rev. 8:80–87 (2005).

    CAS  Google Scholar 

  7. R. G. Bates. Determination of pH. Theory and Practice, 2nd ed. Wiley, New York, 1973, p.90.

    Google Scholar 

  8. K. A. Pikal-Cleland, J. L. Cleland, T. J. Anchordoquy, and J. F. Carpenter. Effect of glycine on pH changes and protein stability during freeze-thawing in phosphate buffer systems. J. Pharm. Sci. 91:1969–1979 (2002).

    Article  PubMed  CAS  Google Scholar 

  9. M. J. Pikal, K. M. Dellerman, M. L. Roy, and R. M. Riggin. The effect of formulation variables on the stability of freeze-dried human growth harmone. Pharm. Res. 8:427–436 (1991).

    Article  PubMed  CAS  Google Scholar 

  10. S. S. Larsen. Studies on stability of drugs in frozen systems. IV. The stability of benzylpenicillin sodium in frozen aqueous solutions. Dansk Tidsskr. Farm. 45:307–316 (1971).

    CAS  Google Scholar 

  11. M. P. W. M. te Booy, R. A. de Ruiter, and A. L. J. de Meere. Evaluation of the physical stability of freeze-dried sucrose-containing formulations by differential scanning calorimetry. Pharm. Res. 9:109–114 (1992).

    Article  PubMed  CAS  Google Scholar 

  12. M. J. Akers, N. Milton, S. R. Byrn, and S. L. Nail. Glycine crystallization during freezing: the effects of salt form, pH, and ionic strength. Pharm. Res. 12:1457–1461 (1995).

    Article  PubMed  CAS  Google Scholar 

  13. A. Pyne and R. Suryanarayanan. Phase transitions of glycine in frozen aqueous solutions and freeze-drying. Pharm. Res. 18:1448–1454 (2001).

    Article  PubMed  CAS  Google Scholar 

  14. S. S. Larsen. Studies on stability of drugs in frozen systems. VI. The effect of freezing on pH for buffered aqueous solutions. Arch. Pharm. Chemi Sci. Ed. 1:41–53 (1973).

    CAS  Google Scholar 

  15. L. van den Berg. pH changes in buffers and foods during freezing and subsequent storage. Cryobiology 3:236–242 (1966).

    CAS  Google Scholar 

  16. L. van den Berg and D. Rose. Effect of freezing on the pH and composition of sodium and potassium phosphate solutions: the reciprocal system: KH2PO4–Na2HPO4–H2O. Arch. Biochim. Biophys. 81:319–329 (1959).

    Article  CAS  Google Scholar 

  17. L. van den Berg and D. Rose. The effect of addition of sodium and potassium chloride to the reciprocal system: KH2PO4–Na2HPO4–H2O on pH and composition during freezing. Arch. Biochim. Biophys. 84:305–315 (1959).

    Article  CAS  Google Scholar 

  18. G. Gomez, M. J. Pikal, and N. Rodriguez-Hornedo. Effect of initial buffer composition on pH changes during far-from equilibrium freezing of sodium phosphate buffer solutions. Pharm. Res. 18:90–97 (2001).

    Article  PubMed  CAS  Google Scholar 

  19. G. Gomez. Crystallization-related pH changes during freezing of sodium phosphate buffer solutions, Ph.D. Dissertation, University of Michigan, Ann Arbor, Michigan, 1995.

  20. Y. Orii and M. Morita. Measurement of the pH of frozen buffer solutions by using pH indicators. J. Biochem. 81:163–168 (1977).

    PubMed  CAS  Google Scholar 

  21. B. S. Chang and C. S. Randall. Use of subambient thermal analysis to optimize protein lyophilization. Cryobiology 29:632–656 (1992).

    Article  CAS  Google Scholar 

  22. N. Murase and F. Franks. Salt precipitation during the freeze-concentration of phosphate buffer solutions. Biophys. Chem. 34:293–300 (1989).

    Article  PubMed  CAS  Google Scholar 

  23. N. Murase, P. Echlin, and F. Franks. The structural states freeze-concentrated and freeze-dried phosphates studied by scanning electron-microscopy and differential scanning calorimetry. Cryobiology 28:364–375 (1991).

    Article  CAS  Google Scholar 

  24. R. K. Cavatur and R. Suryanarayanan. Characterization of frozen aqueous solutions by low temperature X-ray powder diffractometry. Pharm. Res. 15:194–199 (1998).

    Article  PubMed  CAS  Google Scholar 

  25. A. Pyne, K. Chatterjee, and R. Suryanarayanan. Crystalline to amorphous transition of disodium hydrogen phosphate during primary drying. Pharm. Res. 20:802–803 (2003).

    Article  PubMed  CAS  Google Scholar 

  26. N. Blagden, R. Davey, M. Song, M. Quayle, S. Clark, D. Taylor, and A. Nield. A novel batch cooling crystallization for in situ monitoring of solution crystallization using energy dispersive X-ray diffraction. Cryst. Growth Design 3:197–201 (2003).

    Article  CAS  Google Scholar 

  27. R. Surana and R. Suryanarayanan. Quantitation of crystallinity in substantially amorphous pharmaceuticals and study of crystallization kinetics by X-ray powder diffractometry. Powder Diffr. 15:2–6 (2000).

    CAS  Google Scholar 

  28. C. Nunes, R. Suryanarayanan, C. E. Botez, and P .W. Stephens. Characterization and crystal structure of d-mannitol hemihydrate. J. Pharm. Sci. 93:2800–2809 (2004).

    Article  PubMed  CAS  Google Scholar 

  29. C. Nunes. Use of High-Intensity X-Radiation in Solid-State Characterization of Pharmaceuticals, Ph.D. Dissertation, Department of Pharmaceutics, University of Minnesota, 2005.

  30. C. Nunes, A. Mahendrasingam, and R. Suryanarayanan. Quantification of crystallinity in substantially amorphous materials by synchrotron X-ray powder diffractometry. Pharm. Res. 22:1942–1953 (2005).

    Article  PubMed  CAS  Google Scholar 

  31. C. Mohan. Buffers: a guide for the preparation and use of buffers in biological systems. Calbiochem®, EMD Biosciences, Inc. 2003.

  32. A. P. Hammersley. ESRF internal report, ESRF97HA02T, “Fit2D: an introduction and overview,” (1997).

  33. A. P. Hammersley, S. O. Svensson, M. Hanfland, A. N. Fitch, and D. Häusermann. Two-dimensional detector software: from real detector to idealized image or two-theta scan. High Press. Res. 14:235–248 (1996).

    Google Scholar 

  34. Powder Diffraction File. (hexagonal ice: PDF-2, Card #00-042-1142), International Centre for Diffraction Data, Newtown Square, PA, 1996.

  35. Powder Diffraction File. (disodium hydrogen phosphate dodecahydrate: PDF-2, Card #00-011-0657), International Centre for Diffraction Data, Newtown Square, PA, 1996.

  36. D. H. Templeton, H. W. Ruben, and A. Zalkin. Entropy and crystal structure of hydrates of disodium hydrogen phosphate. J. Phys. Chem. 94:7830–7834 (1990).

    Article  CAS  Google Scholar 

  37. A. Ghule, C. Bhongale, and H. Chang. Monitoring dehydration and condensation processes of Na2HPO4•12H2O using thermo-Raman spectroscopy. Spectrochim. Acta, Part A: Mol. Biomol. Spectrosc. 59A(7), 1529–1539, (2003).

    Article  CAS  Google Scholar 

  38. Powder Diffraction File. (crystalline phases of disodium hydrogen phosphate and monosodium dihydrogen phosphate, Na2HPO4•7H2O: PDF-2, Card #00-010-0191; NaH2PO4•2H2O: PDF-2, Card #00-010-0198; NaH2PO4•H2O: PDF-2, Card #00-011-0651; NaH2PO4: PDF-2, Card #00-011-0659), International Centre for Diffraction Data, Newtown Square, PA, 1996.

Download references

Acknowledgments

The authors thank Dr. Douglas Robinson, Advanced Photon Source, Argonne National Laboratory for the beam-line management and support during the experiments. This work was supported, in part, by a Research Challenge award from the Ohio Board of Regents. Use of the Advanced Photon Source (APS) was supported by the U.S. Department of Energy, Basic Energy Sciences, Office of Science, under Contract No. W-31-109-Eng-38. The Midwest Universities Collaborative Access Team (MUCAT) sector at the APS is supported by the U.S. Department of Energy, Basic Energy Sciences, Office of Science, through the Ames Laboratory under Contract No. W-7405-Eng-82. We thank Linda Sauer for her assistance in setting up the instrumentation.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Raj Suryanarayanan.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Varshney, D.B., Kumar, S., Shalaev, E.Y. et al. Solute Crystallization in Frozen Systems–Use of Synchrotron Radiation to Improve Sensitivity. Pharm Res 23, 2368–2374 (2006). https://doi.org/10.1007/s11095-006-9051-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11095-006-9051-0

Key words

Navigation