An experimental study of improved oil recovery through fines-assisted waterflooding

https://doi.org/10.1016/j.petrol.2013.08.031Get rights and content

Highlights

  • A systematic laboratory study is presented to investigate the potential of fines-assisted waterflooding in IOR.

  • Experimental observations are interpreted using recently-developed mathematical and numerical models.

  • Abnormal features are observed in water relative permeability.

  • This abnormal behavior is explained by the expansion of rock surface exposed to low-salinity water.

Abstract

Permeability decline during waterflooding by varying water composition, in particular with low salinity or high pH water, has been observed in numerous laboratory studies. This has been explained by the lifting, migration and subsequent plugging of pores by fine particles. Recently, mathematical models have been presented to investigate the concept of using this permeability decline for mobility control during a waterflood. Now, these models need to be tested against observations during a core flood test.

This paper presents a systematic laboratory study to investigate the underlying physics mechanisms for improved oil recovery as a consequence of injecting low-salinity water. Three sister plugs of Berea sandstone were used in the experiments. The first plug was subjected to single-phase waterflood for permeability measurements with varying salinities from 4 (high-salinity) to 0 (low-salinity) g/L NaCl. Core permeability decreased from 495 to 60 md, confirming the effect of changing water composition on permeability. The second plug saturated with high-salinity water was subjected first to primary oil flood (using Soltrol) to the connate water saturation and then to a benchmark waterflood using the same water. The oil recovery was noted and the core was restored to the connate water by a secondary oil flood. Finally, low-salinity waterflood was carried out and oil recovery was recorded. Experimental observations were interpreted using a numerical model. In order to check the reproducibility of the observations, the same experimental procedure was applied on the third plug. Results confirmed the reproducibility of the observations.

Significant decrease in water relative permeability by approximately 50% and some decrease in residual oil saturation by about 5% were observed during the low-salinity waterflood in comparison with the high-salinity waterflood. Treatment of the low-salinity coreflood data by a numerical model reveals the decrease in water relative permeability with increasing water saturation at high water saturations. This observation is explained by the expansion of rock surface exposed to low-salinity water during the increase of water saturation. The laboratory data matched by the numerical model shows a high surface exponent value (nA=30), which is explained by a sharp surface area rise at high water saturations. The abnormal behavior of water relative permeability in response to low-salinity waterflood has resulted from matching water permeability increase at low water saturations and decrease at high saturations.

Keywords

low salinity coreflood
fines migration
mobility control
enhanced oil recovery
relative permeability

Cited by (0)

View Abstract