An experimental and modeling study to investigate brine-rock interactions during low salinity water flooding in carbonates

https://doi.org/10.1016/j.petrol.2017.11.052Get rights and content

Highlights

  • A geochemical model is developed in UTCHEM-IPHREEQC for wettability alteration.

  • The model parameters are obtained from single phase experiments.

  • The model is validated against low salinity water flood experiments from literature.

  • Divalent ions modulate organic acid concentration on rock surface and wettability.

Abstract

Injection of brines with carefully designed ionic compositions into oil-wet carbonate rocks at high temperatures has shown to alter their wettability towards a water-wet state and improve oil recovery. Various mechanisms have been postulated for this wettability alteration such as mineral dissolution and interaction of potential determining ions, such as Ca2+, Mg2+ and SO42−, with the carbonate surface. In this study, experimental and modeling work was performed to gain further insights into the geochemical interactions between carbonate rocks and modified brines. Single-phase static (equilibrium) and transport experiments were performed with various brines in limestone cores at 120 °C. The ionic compositions of the effluent samples were monitored using ion chromatography. A mechanistic model for the wettability alteration process was developed in UTCHEM-IPHREEQC based on key geochemical interactions. The calcite surface was assumed to consist of positive and negative sites and their interactions with potential determining ions were considered assuming local equilibrium. The model assumed the degree of oil-wetness to depend on the amount of organic acid attached on the surface, which in-turn was dependent on the geochemistry of the system. Results of static experiments performed with crushed limestones and brines showed an increase in calcium concentration and a decrease in magnesium concentration in the supernatant brines. The effluent concentrations from single-phase brine corefloods in limestone cores showed an increase in calcium concentration, a decrease in magnesium concentration and a delay in sulfate concentration. Three key geochemical interactions were identified based on these results: mineral dissolution, surface dolomitization and sulfate adsorption. A good qualitative agreement was observed between single-phase experiments and simulations, suggesting that the model was able to accurately capture the geochemistry. The simulation results showed good agreement with zeta potential and oil recovery results reported in the literature.

Keywords

Low salinity
Wettability alteration
Brine-rock interactions
IPHREEQC
Carbonates
Mechanistic model
Surface complexation

Cited by (0)

View Abstract