Elsevier

Geoderma

Volume 339, 1 April 2019, Pages 20-30
Geoderma

Organomineral phosphate fertilizer from sugarcane byproduct and its effects on soil phosphorus availability and sugarcane yield

https://doi.org/10.1016/j.geoderma.2018.12.036Get rights and content

Highlights

  • Application of FC enhanced PUE in the CLY soil, regardless of the mineral P source.

  • Highest P contents in sugarcane were: SDY > CLY, TSP > control, and +FC > −FC.

  • P in the labile and moderately labile fractions decreased with FC application.

  • Al/Fe-bound species decreased 9, 24 and 3% in RPR, TSP and control, when +FC.

Abstract

The recycling of agricultural by-products to produce organomineral fertilizers and using them as soil amendments to improve soil physical and chemical characteristics is a feasible disposal solution for the sugarcane industry. This study aimed to evaluate the agronomic performance of a bio-based phosphate (P) fertilizer produced from mineral phosphates (Gafsa rock phosphate and TSP) and filter cake (FC) in two distinct soils varying in their particle sizes, namely clayey (CLY) and sandy loam (SDY). Biological tests were carried out to determine the performance of the OF for sugarcane production against commercial P sources. The addition of filter cake (+FC) was responsible for an increase in yield when compared to soils that did not receive it (−FC), yet similar sugarcane production for either soil was obtained. Phosphorus use efficiency (PUE) was ~10% higher in CLY under TSP +FC compared to phosphate rock (RPR) −FC. On the basis of our P fractionation data, the addition of FC decreased P concentrations in the more labile P fractions. Phosphorus X-rays Absorption Near Edge Structure (XANES) analysis indicated that even though P was predominantly associated with Fe- and Al-(hydr)oxides, application of FC led to a change in P speciation, causing a shift from Fe-bound P in the soil that did not receive filter cake into Al-bound P, and to an increase in P associated to organic compounds in the soil receiving this amendment. Our findings showed that PUE and dry matter yield of sugarcane can be increased in weathered soils when organic and inorganic P sources are combined to supply this element.

Introduction

Among all plant macronutrients, phosphorus (P) is arguably the one presenting the lowest use efficiency in terms of crop production. Plant availability of P is largely affected by soil texture and mineralogy, application strategy and P source (Baligar and Bennett, 1986). An insufficient P supply not only limits economically acceptable yields and the inputs of other nutrients, particularly N, that is used less effectively, but it also threatens food security for a growing world population (FAO, 2008).

In highly weathered agricultural soils of the tropics, crop production is positively related to P fertilization. In these soils, the average P application rate is of the order of 25 kg ha−1, in comparison to 12 kg ha−1, the average world application rate (Lu and Tian, 2017). The increasing demand for food, led by the ever-growing world population, represents an important driving force for P fertilization rates to continue to rise, with the immediate consequence of this being the depletion of P reserves on an unprecedented rate (Cordell and Neset, 2014; Jarvie et al., 2015). Because of this, the demand for P fertilizers is currently a big worldwide concern, especially in tropical agricultural soils, where P availability is severely restricted due to their generally high P sorption capacity (PSC) (Abdala et al., 2012, Abdala et al., 2018; Novais et al., 2007; Rodrigues et al., 2016). Therefore, P-fertilizer efficiency is generally low, usually sitting around 10–20% in the short term (Chien et al., 2009).

Research efforts have been made to reduce the P footprint by using less synthetic P fertilizers (Caione et al., 2015; Vasconcelos et al., 2017; Withers et al., 2018). This in turn has triggered the search for alternative P sources, usually wastes generated in agricultural operations, which can act not only as a source of this nutrient but also controlling P release, to produce more sustainable whereas agronomically efficient P fertilizers (Ahlgren et al., 2013; Alavi et al., 2017; Caione et al., 2015; Dotaniya and Datta, 2014). Particular attention has been drawn to the recycling of agricultural residues for fertilizer production as it represents an alternative to the highly soluble, high cost-effective traditional P fertilizers (Vasconcelos et al., 2017; Withers et al., 2018). Bio-based P fertilizers not only provide P among other nutrients to plants but may well act as a source of organic matter, besides representing a way of refraining to further explore existing and new P reserves.

The sugar-energy sector has for long been using by-products generated in the industrial process as soil amendments to increase sugarcane yield, by improving soil physical and chemical characteristics (Dotaniya and Datta, 2014; Vasconcelos et al., 2017). Among these by-products is the material obtained from the purification of the sugarcane broth by a filter press, termed filter cake (FC). Subsequently, the FC is open-air composted in order to drop the C:N ratio and is usually mixed with mineral nutrient sources to serve as a fertilizer. The FC is usually applied with phosphate fertilizers at the bottom furrow prior to sugarcane planting as an attempt to increase P use efficiency (PUE) by the crop (Caione et al., 2015).

Research has shown that the combined use of organic and mineral materials to supply P in soils with a high PSC is a feasible way to enhance PUE by plants (Caione et al., 2015; Withers et al., 2018). These studies suggest that the adoption of less soluble P sources, such as rock phosphate, and the application of composted organic materials may increase crop yield as a consequence of reducing soil P fixation capacity (Dotaniya and Datta, 2014; Eghball et al., 1996; Singh et al., 1988), thus improving P acquisition by plants. Trials conducted inside commercial sugarcane areas proved that the association of inorganic P sources and FC has increased crop yields (Vasconcelos et al., 2017). Other studies relying on the associated use of mineral and organic P sources for sugarcane showed that it not only increased crop yield, but also sugar accumulation (Caione et al., 2015).

One way of gaining insight into the reactivity of an element in soils is by obtaining information on the chemical forms it is presented in that medium. The chemical associations of P with other elements abundant in soil environments, e.g., Al, Fe, Si, Ca, etc.… largely influence P dynamics and thus its availability to plants. The procedure proposed by Hedley et al. (1982) to fractionate P allows the quantification of different operationally defined pools, measuring concomitantly the inorganic and organic P in distinct fractions, increasing the recalcitrance of the pools according to the extractant strength. This technique can predict P availability for plant uptake (Cross and Schlesinger, 1995). However, its isolated use limits a more in-deep assessment of environmental aspects of P management. Synchrotron-based K-edge XANES spectroscopy has for long been used for chemical speciation studies of P in soils (Beauchemin et al., 2003; Hesterberg et al., 1999) because it represents a successful means for directly determining the chemical species of this element present in a sample. Besides, this technique also offers some advantages over its conventional counterparts as little or virtually no sample preparation and chemical treatment prior to the analysis is required (Vogel et al., 2018). Because P K-edge XANES provides the actual chemical state of the absorber element, it can be used to indicate whether the element is bound to a mineral surface or associated to an organic compound (Kruse et al., 2015).

The aim of this study was to evaluate how the associated use of mineral P sources with an organic material, i.e., filter cake, performs in terms of sugarcane yield in relation to commercial P sources. A pot experiment was therefore set out using different inorganic P fertilizers sources amended with FC, and sugarcane production was evaluated by the end of each harvest and PUE at the end of the experiment. It was also our objective to determine how P was partitioned and what chemical P species were left in the soils receiving the different treatments, to which we used sequential chemical fractionation (SCF) of soil P in association with P-XANES spectroscopy, respectively.

Section snippets

Material and methods

This study was carried out at the Brazilian Center for Research in Energy and Materials (CNPEM), in Campinas, Brazil. Fertilizer production and pot trial were conducted at the Brazilian Bioethanol Science and Technology Laboratory (CTBE) and P-XANES measurements were performed at the Brazilian Synchrotron Light Laboratory (LNLS). Sequential chemical fractionation (SCF) of soil phosphorus was done at the Soil Science department at the College of Agriculture ‘Luiz de Queiroz’ (ESALQ/USP).

Sugarcane yield and PUE

Significant soil × FC and soil × P source interactions were observed for cumulative sugarcane DM yield (Table 2). In the CLY, the addition of FC in the fertilizer increased DM productivity in ~30%, whereas the same trend was not observed for the SDY. However, the DM yield in the SDY was higher than in the CLY, regardless of FC addition. Among P sources, higher yields were attained when TSP was used for either soil, accounting for as much as 22% higher when compared with RPR and control.

Conclusions

The associated use of TSP with FC was shown to improve the availability of soil P, whereby increases in PUE and sugarcane biomass production were possible. From an environmentally friendly standpoint, the recycling of FC for the production of organomineral P fertilizers represents a way of decreasing the reliance on chemical fertilizers, which has a direct impact on alleviating the production costs of crops, provided the high prices of these inputs. Furthermore, it also provides a safe and

Acknowledgements

The authors would like to acknowledge CNPq - Conselho Nacional de Desenvolvimento Científico e Tecnológico for founding the research, Grant 403503/2013-2. Research supported by CTBE – Brazilian Bioethanol Science and Technology Laboratory, CNPEM/MCTIC and LNLS – Brazilian Synchrotron Light Laboratory, CNPEM/MCTIC.

References (58)

  • E. Hou et al.

    Solubility of phosphorus in subtropical forest soils as influenced by low-molecular organic acids and key soil properties

    Geoderma

    (2018)
  • N. Khare et al.

    Phosphate bonding configuration on ferrihydrite based on molecular orbital calculations and XANES fingerprinting

    Geochim. Cosmochim. Acta

    (2007)
  • M. Koch et al.

    Phosphorus stocks and speciation in soil profiles of a long-term fertilizer experiment: evidence from sequential fractionation, P K-edge XANES, and31P NMR spectroscopy

    Geoderma

    (2018)
  • D. Lu et al.

    Speciation of Cu and Zn during composting of pig manure amended with rock phosphate

    Waste Manag.

    (2014)
  • J. Murphy et al.

    A modified single solution method for the determination of phosphate in natural waters

    Anal. Chim. Acta

    (1962)
  • P.S. Pavinato et al.

    Phosphorus fractions in Brazilian Cerrado soils as affected by tillage

    Soil Tillage Res.

    (2009)
  • M. Rodrigues et al.

    Legacy phosphorus and no tillage agriculture in tropical oxisols of the Brazilian savanna

    Sci. Total Environ.

    (2016)
  • G.S. Toor et al.

    Advances in the Characterization of Phosphorus in Organic Wastes: Environmental and Agronomic Applications

    (2006)
  • R. de L. Vasconcelos et al.

    Filter cake in industrial quality and in the physiological and acid phosphatase activities in cane-plant

    Ind. Crop. Prod.

    (2017)
  • J. Ahlgren et al.

    Identification and quantification of organic phosphorus forms in soils from fertility experiments

    Soil Use Manag.

    (2013)
  • B. Ajiboye et al.

    Experimental validation of quantitative XANES analysis for phosphorus speciation

    Soil Sci. Soc. Am. J.

    (2007)
  • K.O. Andersson et al.

    XANES demonstrates the release of calcium phosphates from alkaline vertisols to moderately acidified solution

    Environ. Sci. Technol.

    (2016)
  • F.V. Andrade et al.

    Adição de ácidos orgânicos e húmicos em Latossolos e adsorção de fosfato

    Rev. Bras. Ciênc. Solo

    (2003)
  • V.C. Baligar et al.

    NPK-fertilizer efficiency - a situation analysis for the tropics

    Fertil. Res.

    (1986)
  • S. Beauchemin et al.

    Speciation of phosphorus in phosphorus-enriched agricultural soils using X-ray absorption near-edge structure spectroscopy and chemical fractionation

    J. Environ. Qual.

    (2003)
  • S.M. Bokhtiar et al.

    Effects of organic and inorganic fertilizer on growth, yield, and juice quality and residual effects on ratoon crops of sugarcane

    J. Plant Nutr.

    (2008)
  • G. Caione et al.

    Response of sugarcane in a Red Ultisol to phosphorus rates, phosphorus sources, and filter cake

    Sci. World J.

    (2015)
  • S.H. Chien et al.

    Chapter 8 recent developments of fertilizer production and use to improve nutrient efficiency and minimize environmental impacts

  • M.J.A. Coelho et al.

    Utilization and fate of phosphorus of different sources applied to cohesive soil of Amazonian periphery

    Sci. Agric.

    (2017)
  • Cited by (41)

    • Chemical and spectroscopic evaluations supporting superior P availability after biochar-P fertilizer application

      2022, Soil and Tillage Research
      Citation Excerpt :

      Biochar is heralded for releasing dissolved organic C compounds (Rajapaksha et al., 2019) or to be a trigger for soil soluble C compounds release (Smebye et al., 2016), involving a mixture of organic compounds such as humic/fulvic-like, small fused-ring aromatics, aliphatic C, and carboxyl C molecules (Liu et al., 2019) that inhibit or decrease P adsorption in the soil mineral phase (Barreto et al., 2020; Schneider and Haderlein, 2016; Weng et al., 2012). Biochar has been a promisor alternative not only as P source (Borges et al., 2019; Parvage and Ulén, 2013; Schneider and Haderlein, 2016) but also as a matrix to host P fertilizer and improve its use efficiency. Conventional phosphate fertilizer (triple superphosphate - TSP) coated by biochar, for example, increased by 10% and 20% P uptake and P recovered by the plant, respectively, than TSP alone (Pogorzelski et al., 2020).

    • Speciation and pH- and particle size-dependent solubility of phosphorus in tropical sandy soils

      2022, Geoderma
      Citation Excerpt :

      A direct method for identifying and quantifying P speciation in soil and environmental samples is the P K-edge X-ray Absorption Near-Edge Structure (XANES) spectroscopy (Prietzel et al., 2016). This spectroscopic technique has been used in various agricultural and environmental studies to determine the chemical species of P in agricultural soils for different crop and fertilizer management options across temperate and tropical regions (Abdala et al., 2015, 2020; Antonangelo et al., 2020; Borges et al., 2019; Eriksson et al., 2015; Gatiboni et al., 2021; Gu et al., 2020; Gustafsson et al., 2012). Research has shown a wide variation in P speciation in soil samples, including P species adsorbed to mineral solids, P incorporated in Ca-, Fe- and Al-phosphate minerals, and organic P compounds, with varying contributions to total P, depending on soil types and soil management.

    • A spatially explicit assessment of sugarcane vinasse as a sustainable by-product

      2021, Science of the Total Environment
      Citation Excerpt :

      The outstanding N2O emissions abatement from biodigested vinasse use in sugarcane soils and the associated savings on mineral fertilizers acquisition costs (for the replacement of NPK) are supportive pathways for a circular economy for the sugar and ethanol supply chain. The present study shows the importance of using bio-products from the sugarcane production (sugar and/or ethanol) for generating biofertilizer, as indicated by B.M.M.N. Borges et al. (2019). Moreover, it collaborates in decreasing GHG emissions, mainly from N alternative fertilization (C.D. Borges et al., 2019).

    • Anaerobic co-digestion of agro-industrial waste with cheese whey: Impact of centrifuge comminution on biogas release and digestate agrochemical properties

      2021, Biomass and Bioenergy
      Citation Excerpt :

      It is important not only to optimize the technology of anaerobic fermentation but also to study the effect of the application of the obtained organo-mineral fertilizers on the quality of crops. Today there is a tendency to reduce the doses of mineral fertilizers to maintain the natural fertility of soil [12]. For economic and environmental reasons, along with mineral fertilizers, the possibilities of microbiological plant protection products and complex organo-mineral fertilizers containing easily digestible humic complexes are widely investigating [13].

    • Use of compost and phosphate-solubilizing bacteria affect sugarcane mineral nutrition, phosphorus availability, and the soil bacterial community

      2021, Applied Soil Ecology
      Citation Excerpt :

      The application of organic amendments, which potentially reduce soil P fixation capacity, can therefore provide a source of increased P availability for plant nutrition (Lemming et al., 2019). Filter cake application combined with a soluble mineral fertilizer can increase crop yield and P availability in soil (Borges et al., 2019). Another strategy for sugarcane fertilization, involving inexpensive sources, is the use of rock phosphate as source of P (de Sousa et al., 2015).

    View all citing articles on Scopus
    View full text